Tech Tip: Passat Coolant Leak at Engine Oil Cooler Hose

Tech Tip: Passat Coolant Leak at Engine Oil Cooler Hose

Some 2000 VW Passats with the 2.8 V6 5V engine may exhibit coolant leaking at the oil cooler hose. The problem may be caused by the oil cooler turning when the oil filter is removed or installed.

Some 2000 VW Passats with the 2.8 V6 5V engine may exhibit coolant leaking at the oil cooler hose. The problem may be caused by the oil cooler turning when the oil filter is removed or installed.

Service Procedure
1. When replacing the oil filter:
• Observe the oil cooler when loosening the oil filter.
Note: If necessary, hold the oil cooler while removing the filter. If the cooler moves too far, damage to the coolant hose may result.
2. If the oil cooler moves from its original position:
• With the oil filter removed, loosen the oil cooler nut and adjust the cooler back to its original position.
3. Check the oil cooler hose. It shouldn’t be twisted or pinched.
4. Tighten the oil cooler nut. Torque should be 30 Nm.
5. Install the oil filter and hand-tighten it, making sure the oil cooler doesn’t move.
6. Inspect the cooler hose to ensure that it isn’t twisted or pinched.

Technical service bulletin courtesy of ALLDATA.

For additional tech tips, visit www.alldata.com.

You May Also Like

Fuel Pumps and Cranking

Diagnosing the problem comes down to understanding what causes a loss of fuel pressure.

Here is a diagnostic puzzle: An owner comes to your shop complaining that it takes longer than expected to start his car’s engine in the morning. There are no codes for the crankshaft and camshaft sensors. And, the oil pressure is within specifications. If you are lucky, you might have a code for low fuel pressure on the high side of the direct injection system. What could be the source of the problem?

Electric Power Steering Diagnostics

Load management for steering systems.

Solving VW False Fuel Pressure Reading

First, verify the customer did not run out of fuel at the time the DTCs were stored.

vw steering wheel squeak
Tech Tips for Dorman’s OE FIX Steering Tie Rod End Assembly

Read the tech note for tips on installation of this unique fix.

Acura Frozen Starter Causes No Start

Why won’t the engine crank after the vehicle has been exposed to precipitation and then freezing temperatures?

Other Posts

Don’t Miss The April Digital Edition of ShopOwner

The April issue includes technical and management content and is free to download.

Now Available – March’s Digital Edition of ShopOwner

The March issue includes technical and management content and is free to download.

Now Available – February’s Digital Edition of ShopOwner

February’s issue includes technical and management content and is free to download.

How To Service BMW Tire Monitor Systems

BMW has offered Tire Pressure Monitoring Systems (TPMS) for more than 20 years. These early indirect and direct systems were implemented not to meet the 2007 government mandate but to inform the driver when an expensive Michelin or Bridgestone run-flat tire was deflating. Some 2002 and 2003 models have an indirect system called Flat Tire