VW Four Motion

VW DSG Maintenance

A DSG transmission is lighter than a comparable automatic with the same number of speeds.

Most of the drivers who own a Volkswagen car or truck with a Direct Shift Gearbox (DSG) will not know they have a dual-clutch transmission connected to the engine. Most of them will think they have an automatic that gets excellent gas mileage. It is not until a transmission component fails or a service interval elapses that they learn about DSG.

WHY DSG?

A DSG transmission is lighter than a comparable automatic with the same number of speeds. And, less weight equals better fuel efficiency. Internally, the dual-clutch transmission is more efficient than an automatic because there are fewer moving parts. With an automatic transmission, the engine has to drive a pump and energy is lost in the torque converter and clutch packs.

LUBRICATING HYDRAULIC FLUID

Instead of a linkage connected to a shifter, the shift forks are actuated by hydraulic solenoids. The actual shifting is done by opening one clutch and closing the other, and maintaining the power flow. The shifting behavior can be fine-tuned by software that allows very different characteristics using the same DSG transmission.

VW uses a wet clutch setup. The transmission fluid lubricates and cools the clutches, and it contains friction modifiers that influence the friction level of the clutches. These additives can become depleted over time.

The same fluid that lubricates the clutches also lubricates the internal components of the transmission. Like with a manual transmission, the shock loads of the gears can degrade the fluid over time.

The fluid also acts as a hydraulic fluid. Hydraulic solenoids engage the DSG clutch and gears on the shafts. If the fluid is contaminated or oxidized, it can damage the solenoid’s seals causing internal leaks, or gum up the operation of the solenoid.

FLUID SERVICE

Fluid maintenance is key in keeping a VW DSG transmission operating as designed. Volkswagen recommends a 150,000-mile fluid service interval for most DSG transmissions, but recommends a more frequent service interval if the vehicle is used for severe-duty or towing applications. Check the service information for the correct interval.

Most DSG transmissions have a cartridge filter on top of the transmission. Unfortunately, it is under the battery and/or air filter housing. Replace the filter before you drain the transmission. The housing contains the most contaminated fluid. Draining the filter housing causes this fluid to go back into the case.

VW’s specification for most DSG transmissions is G 052 182 A2, G 052 182 A6 or TL 521 82. Make sure the replacement fluid meets or exceeds these specifications.

Reflashing and Reprogramming

You might not consider the software for the DSG transmission as a maintenance item, but updating the software can add more longevity to the unit’s clutches. One of the more common types of TSBs issued by Volkswagen has been for improvements to engine control modules and transmission control software. 

Some of these improvements go back as far as 2008 models. As a rule, it is recommended that you make sure the Volkswagen you are working on has the latest ECM calibrations. The new calibrations can help to keep the check engine light off and prolong the life of the engine and transmission.

Some TSBs require programming with new calibrations to correct problems. The new software can improve shift quality, resolve hesitation and reduce clutch noise problems. Checking for these software updates before replacing the clutch or gearbox can help to repair the vehicle right the first time.

You May Also Like

VarioCam: Understanding Porsche’s VVT Technology

Originally developed for the 2001 Porsche 911 Turbo, VarioCam changes the valve timing to increase power & reduce emissions.

VarioCam and VarioCam Plus are Porsche’s patented variable valve timing and valve lift technologies that have evolved over the past two decades. Originally developed for the 2001 Porsche 911 Turbo, VarioCam changes the valve timing to increase power and reduce emissions. 

VarioCam Plus on later models can adjust valve lift by controlling oil to the upper part of the lifter. The lifter can ride on two different profiles on the camshaft. But, the oil passages can become clogged if an oil change is neglected.

Mercedes 4MATIC Diagnostics

The Mercedes-Benz 4MATIC all-wheel drive (AWD) systems have been around for a while now.

Mercedes-Benz Auxiliary Water Pump Diagnostics

These pumps will show up on more and more vehicles as engines become more efficient and generate less excess heat.

Timing BMW VANOS N53 And N54 

To service them, you will need the appropriate toolset to lock the crank and camshaft.

Jaguar V6 Timing Chain Service

When a guide and tensioner fail, it induces timing chain slap that causes the chain to jump on the sprockets.

Other Posts

Now Available – June’s Digital Edition of ShopOwner

The June issue includes technical and management content and is free to download.

Don’t Miss The May Digital Edition of ShopOwner

The May issue includes technical and management content and is free to download.

Exhaust Gas Recirculation Operation and Diagnosis

Since exhaust gas does not burn, this lowers the combustion temperatures and reduces NOx emissions from the engine.

Don’t Miss The April Digital Edition of ShopOwner

The April issue includes technical and management content and is free to download.