Tech Tip: Kia Constant Variable Valve Timing (CVVT) Oil Control Valve Inspection

Tech Tip: Kia Constant Variable Valve Timing (CVVT) Oil Control Valve Inspection

This bulletin provides information related to the Oil Control Valve (OCV) used in Constant Variable Valve Timing (CVVT) systems. If, at any time, the OCV is suspected as a cause of rough idling, poor acceleration, camshaft timing misalignment-related trouble codes, misfire-related trouble codes, etc., on a Kia vehicle equipped with a CVVT system, be sure to perform the OCV inspection procedure below before replacement.

This bulletin provides information related to the Oil Control Valve (OCV) used in Constant Variable Valve Timing (CVVT) systems. If, at any time, the OCV is suspected as a cause of rough idling, poor acceleration, camshaft timing misalignment-related trouble codes, misfire-related trouble codes, etc., on a Kia ­vehicle equipped with a CVVT system, be sure to perform the OCV inspection procedure below before ­replacement.

If the OCV operates normally, inspect for other ­engine malfunctions. Do not replace the OCV.

Note: Make sure the oil filter is OE; aftermarket oil filter flow rates differ and may affect the CVVT ­system’s performance. See Fig. 1. figure 1

Related Diagnostic Trouble Codes:

P0011 – “A” camshaft position – Timing over-­advanced or System performance (Bank 1)

P0012 – “A” camshaft position – Timing over-­retarded (Bank 1)

P0014 – “B” camshaft position – Timing over-­advanced or System performance (Bank 1)

P0015 – “B” camshaft position – Timing over-­retarded (Bank 1)

P0016 – Crankshaft position-Camshaft position ­correlation (Bank 1 Sensor A)

P0018 – Crankshaft position-Camshaft position ­correlation (Bank 2 Sensor A)

P0021 – “A” camshaft position – Timing over-­advanced or System performance (Bank 2)

P0022 – “A” camshaft position – Timing over-­retarded (Bank 2)

P0300 – Random/Multiple cylinder misfire detected

Basic Inspections:

– Monitor the waveforms of the crankshaft and camshaft position sensors with GDS.

– Check if the OCV connectors are securely connected and the pin tension is correct.

– Check that OCV connector seals are well seated; LH and RH OCVs are installed in place.

Note: The LH and RH OCV connectors are different in colors on V6 configurations.

– Measure resistance between the OCV power and ground terminals.

  > If resistance is within specifications, proceed to the OCV Test: Determine if OCV operates normally by providing 12V power and ground.

    – OCV is operating as designed; inspect other ­related areas.

  > If resistance is not within specifications, replace the affected OCV. (See chart below.)

OCV Supplier OCV Coil resistance (at 68° F)

Denso             6.9 ~ 7.9 Ω

Delphi             6.7 ~ 7.7 Ω

Siemens          6.8 ~ 8.0 Ω

– If the OCV does not move or cycle, examine for foreign objects like flashing or aluminum chips ­inside the OCV.

  > If no foreign objects are found, replace the OCV. 

  > If foreign objects are found in the OCV, remove the foreign material and then verify that the DTC or driveability concern is corrected.

1. Measure the resistance between the OCV power and ground terminals.

Measured Resistance (68° F)          Action to Take

Denso (6.9 ~ 7.9Ω)                  Check if the OCV

Delphi (6.7 ~ 7.7Ω)                  operates normally by

Siemens (6.8 ~ 8.0 Ω)             providing 12V power.

                                                (See Step 2.)

Infinity                                      Open circuit →

                                                Replace the OCV.

Abnormally low or                   Short circuit →

zero resistance                        Replace the OCV.

 

2. Check if the OCV operates normally by providing a 12V power supply. Do not apply voltage for longer than five seconds at a time; do not overheat the OCV windings. figure 2

Note: Careful attention is necessary to avoid a short circuit when providing the OCV with 12V power ­because the spacing between the OCV power and ground terminals is very narrow.

3. When 12V power is provided to the OCV, the OCV must move forward as shown in Fig 2.

A: Maximum retarded valve timing condition (12V not provided), Normally open. Figure 3

B: Maximum advanced valve timing condition (12V provided), Closed when energized.

4. If the OCV does not move forward, examine it carefully for a foreign object like an aluminum chip or flashing, which maybe jammed inside the OCV passage. See Fig. 3.

– Blow out the foreign object using compressed air, reuse the OCV and then verify that the fault is corrected.

The OCV can be replaced for the following conditions:

• Resistance is out of specification

• Valve does not move when voltage is applied

• Foreign debris cannot be removed from the OCV.

Courtesy of Kia Motors America.

 

 

You May Also Like

Snap-on Announces Latest Software Release

The latest software includes new coverage, guided component tests and features.

Snap-on announced its spring software release which it says "drives unparalleled confidence from the moment a Snap-on scan tool is turned on with its general and collision repair coverage and industry exclusive features for domestic, Asian and European vehicles."

Not only does the latest software include new coverage, guided component tests and features, but it also contains everything from previous releases for smarter fixes that lead to complete repairs and satisfied customers, according to Snap-om.

Nissan Electro Hydraulic Steering

Nissan’s steering system is susceptible to driver-error.

Toyota Regenerative Braking System

The brake system of a hybrid may have multiple components to perform regenerative braking and pedal simulation.

Regenerative Braking Service

Regenerative braking takes the forward motion of the vehicle and turns it into electrical energy.

Toyota Prius Battery Codes P0A7F, P2011 and P0A80

A second generation Toyota Prius is at least 12 years old and batteries may need to be replaced. Here’s what the codes mean.

Other Posts

Timing BMW VANOS N53 And N54 

To service them, you will need the appropriate toolset to lock the crank and camshaft.

Don’t Miss The April Digital Edition of ShopOwner

The April issue includes technical and management content and is free to download.

VW/Audi PCV Service

The PCV valve regulates the flow of gases from the crankcase.

Continental Tire Opens Retread Solutions Center in South Carolina

The company said it hopes to uncover new improvements and technologies to innovate the retread process.