Some 2002-’05 Sedona (GQ) vehicles may exhibit a humming noise and vibration when the A/C is turned on. To address this condition, replace the A/C compressor bracket with P/N 1K52Y 15810FFF.
Repair Procedure:
1. Disconnect the negative battery cable.
2. Loosen the three mounting bolts (10 mm) to remove the air intake hose.
3. Loosen one low-side pressure line mounting bracket bolt (10 mm).
4. Connect the A/C charge and recovery system to the vehicle, and recover all R-134a refrigerant from the A/C system.
5. Lift the vehicle off the ground and loosen the 10 mounting bolts (10 mm) to remove the under cover.
6. Remove the right front wheel and wheelhouse shield.
7. Remove the serpentine drive belt by first loosening the center bolt of the pulley.
8. Loosen the adjustment bolt and remove the belt.
9. Remove the idler pulley bracket from the main A/C bracket by removing the three bolts (14 mm).
10. Remove the A/C high- and low-pressure lines from the A/C compressor by loosening two bolts (14 mm).
11. Disconnect the compressor clutch wiring, then remove the compressor from the bracket by loosening four bolts (14 mm).
12. Disconnect the alternator wiring connector and loosen the four bolts (14 mm) to remove the alternator.
13. Loosen the five bolts (14 mm) to remove the original A/C compressor bracket.
14. Remove the idler pulley bracket from the new A/C compressor bracket before installation.
15. Using the reverse process, reinstall all the components, making sure all A/C system sealing surfaces are dry and clean. Add a small amount of PAG oil to the A/C line O-rings before assembly.
16. Using the A/C charge and recovery system, apply a vacuum to the vehicle and check for any leakage.
17. After confirming there is no leakage, charge the A/C system with PAG oil. (Min. 30 cc)
18. Charge the A/C system with the correct amount of R-134a refrigerant.
• Production Date – Job 1 to 06-21-03, 1,000 gram;
• Production Date – 06-22-03 to 11-22-04, 1,150 gram; and
• Production Date – 11-23-04 and later, 1,050 gram.
19. Verify proper engine, alternator and A/C operation, and confirm correction of the original A/C humming noise.
Courtesy of Identifix.