Pulling Codes - A Hybrid Story: The Story Of P1A10

Pulling Codes – A Hybrid Story: The Story Of P1A10

This article documents the code P1A10-Hybrid Powertrain Control Module-Battery Disabled found on a 2006 Ford Escape Hybrid 2.3L. Code P1A10 involves a possible interlock problem with the system. Our subject vehicle was a former police vehicle purchased at an auction - for $1! - in very poor condition. It does not run or power up, and both cluster displays are blank.

photo 1

This article documents the code P1A10-Hybrid Powertrain Control Module-Battery Disabled found on a 2006 Ford Escape Hybrid 2.3L. See Photo 1. Code P1A10 involves a possible interlock problem with the system.

Our subject vehicle was a former police vehicle purchased at an auction — for $1! — in very poor condition. It does not run or power up, and both cluster displays are blank.

The vehicle was brought into a local shop where a review of the parameter indicator data (PID) shows per a freeze frame that the interlock circuit was closed at the time of failure. figure 1

See Figure 1.

figure 2The battery pack state of charge is 0% and it appears that the vehicle may have been under water for a period of time.

See Figure 2.

photo 2A visual inspection of the battery implies that based on appearance, there may have been water in this area. See Photo 2. It’s interesting to note that Ford has indicated in their service information that this battery is water resistant.

Further review of PID data shows no interpretation by the system that any cell failure had occurred. The information provided by Ford Motor Company indicated that the battery state of charge needs to be a minimum of 30% in order to begin a diagnostic game plan.

photo 3photo 4photo 5The data does show one more piece to this puzzle: this HV system was in limited operating strategy, the PATS (passive anti-theft system) has also been enabled.

A review of the schematic shows that this system has two inertia switches. One is located in the front of the vehicle and the other one is in the rear of the vehicle. We start by checking to see if the two switches have been opened. The inspection shows that both switches are closed. The switches were then checked for proper feed and ground. The front switch showed 12 volts and a good ground, and the rear switch showed 2.24 volts and a good ground. See Photos 3-5.

It was quite clear that the voltage was incorrect; the question was, what was causing this incorrect voltage level? It was clear that we would have to work our way with a schematic, which would be our roadmap to possibly finding the fault.

photo 6photo 7Following the schematic, we inspected the wiring, which showed the problem — the main harness for the system was cut clear through (Photos 6 and 7).

After the harness was repaired, the vehicle started and ran. A jump-start switch (Photo 8) was depressed so it could be used as a donor to promote the charging of the HV battery. This is achieved per a jump-start control module inside the high voltage traction battery. If the battery reaches a state of charge of 30%, it can be driven. The charge state reached 52.3% and the system appears to be working as designed.

I checked with this owner several months later and the vehicle is being used on a daily basis with no signs of adverse operation. This Pulling Codes case is now closed.   Photo 8

You May Also Like

Philips Announces GoPure GP5212 Automotive Air Purifier

It uses a 3-layer filter to deliver cleaner, healthier, fresher air on the go, Lumileds said.

Lumileds offers the Philips GoPure GP5212 Automotive Air Purifier for drivers and families who suffer from seasonal allergies. Powerful, compact, and simple to use, GoPure GP5212 effectively filters out airborne allergens including pollen and mold that can pass through the cabin filters typically found in passenger vehicles, the company said.

Toyota Regenerative Braking System

The brake system of a hybrid may have multiple components to perform regenerative braking and pedal simulation.

Regenerative Braking Service

Regenerative braking takes the forward motion of the vehicle and turns it into electrical energy.

Toyota Prius Battery Codes P0A7F, P2011 and P0A80

A second generation Toyota Prius is at least 12 years old and batteries may need to be replaced. Here’s what the codes mean.

Air Ride Diagnostics: Reservoirs and Compressors

The secret to diagnosing air ride problems is knowing what criteria the system uses to regulate the compressor/reservoir and having the right tool.

Other Posts

Exhaust Gas Recirculation Operation and Diagnosis

Since exhaust gas does not burn, this lowers the combustion temperatures and reduces NOx emissions from the engine.

Timing BMW VANOS N53 And N54 

To service them, you will need the appropriate toolset to lock the crank and camshaft.

Don’t Miss The April Digital Edition of ShopOwner

The April issue includes technical and management content and is free to download.

VW/Audi PCV Service

The PCV valve regulates the flow of gases from the crankcase.