Tech Tip: Chrysler Minivans May Need Revised Oil Filter Adapter

Tech Tip: Chrysler Minivans May Need Revised Oil Filter Adapter

You or a customer who drives a Chrysler minivan may notice oil wicking from the oil filter gasket or the oil cooler gasket. Inspect the oil filter or oil cooler gasket for scratches or cuts. If any damage exists, perform the Repair Procedure ....

By Jeff Webster, ALLDATA

You or a customer who drives a Chrysler minivan may notice oil wicking from the oil filter gasket or the oil cooler gasket. Inspect the oil filter or oil cooler gasket for scratches or cuts. If any damage exists, perform the Repair Procedure.

Vehicles affected: 2001-’03 Chrysler Town & Country, Dodge Caravan, Plymouth Voyager with a 3.3L or 3.8L engine.

Repair Procedure
1. Raise the vehicle on a hoist.

2. Remove the oil filter.

Caution: When servicing the oil filter, avoid deforming the filter can by installing the remove/install tool band strap against the can-to-base lock seam. The lock seam joining the can to the base is reinforced by the base plate.

a. Using a suitable oil filter wrench, turn the filter counterclockwise to remove from the oil filter adapter (see Figure 1). Properly discard the used oil filter.

3. Remove the oil cooler attachment fitting and oil cooler, if equipped.

4. Disconnect the oil pressure switch electrical connector.

5. Remove the oil filter adapter attaching bolts.

6. Remove the oil filter adapter and seal.

7. Install the revised oil filter adapter, P/N 04781163AC, and gasket, P/N 04781166M. Tighten the attaching bolts to 28 Nm (250 in.-lbs.).

8. Connect the oil pressure switch electrical connector.

9. Install the oil cooler with the new gasket, P/N 05093807M. Tighten the oil cooler fitting to 27 Nm (240 in.-lbs.).

10. Lower the vehicle on the hoist.

11. Fill the oil to the proper level.

12. Start the engine and inspect for leaks.

Courtesy of ALLDATA.

For additional information, visit www.alldata.com.

You May Also Like

Fuel Pumps and Cranking

Diagnosing the problem comes down to understanding what causes a loss of fuel pressure.

Here is a diagnostic puzzle: An owner comes to your shop complaining that it takes longer than expected to start his car’s engine in the morning. There are no codes for the crankshaft and camshaft sensors. And, the oil pressure is within specifications. If you are lucky, you might have a code for low fuel pressure on the high side of the direct injection system. What could be the source of the problem?

Electric Power Steering Diagnostics

Load management for steering systems.

Solving VW False Fuel Pressure Reading

First, verify the customer did not run out of fuel at the time the DTCs were stored.

vw steering wheel squeak
Tech Tips for Dorman’s OE FIX Steering Tie Rod End Assembly

Read the tech note for tips on installation of this unique fix.

Acura Frozen Starter Causes No Start

Why won’t the engine crank after the vehicle has been exposed to precipitation and then freezing temperatures?

Other Posts

Strut Sales

It all comes down to educating the customer about the benefits and asking for the sale.

Beating the Tech Shortage Through Mentoring

How understanding the 80/20 Rule and creative mentoring can make the shortage less threatening.

Nissan Key Will Not Start

Nissan keys use radio frequencies (RF) similar to other everyday wireless devices.

Taking the Fear out of ASE Testing

Spring registration now open; Register by June 30.