Tech Tip: Delayed Transaxle Engagement at Start-Up on Chrysler Vehicles

Tech Tip: Delayed Transaxle Engagement at Start-Up on Chrysler Vehicles

If you encounter a vehicle with intermittent delayed transmission engagement at vehicle start-up in excess of three seconds (transaxle may be cold or hot), check the transaxle fluid level while the vehicle is on a level surface and the transaxle is at normal operating temperature using the following procedure detailed in this Tech Tip.

Affected Vehicles:
1993: (AC) Dynasty/New Yorker/New Yorker Salon; (AG) Daytona; (AY) Imperial/New Yorker Fifth Avenue
1993-’94: (AP) Shadow/Shadow Convertible/ Sundance
1993-’95: (AA) Spirit/Acclaim/LeBaron Sedan; (AJ) LeBaron Coupe/Convertible; (AS) Town & Country/Caravan/Voyager; (ES) Chrysler Voyager (European market); and (LH) Concorde/Intrepid/ LHS/New Yorker/Vision

Note: This bulletin applies to vehicles with 41TE and 42LE transaxles built before Nov. 15, 1994 (transaxle ID code number XXX-2163-XXXX).

Symptom/Condition
Intermittent delayed transmission engagement at vehicle start-up in excess of three seconds. The transaxle may be cold or hot.

Diagnosis
Check the transaxle fluid level while the vehicle is on a level surface and the transaxle is at normal operating temperature using the following procedure.

Start the engine and allow to idle for minimum of one minute. With the parking brake and the service brakes applied, move the gear selector lever momentarily to each gear position. Place the gear selector lever in either Park or Neutral.

Check the transaxle fluid level; It should be in the HOT range of the dipstick. Adjust the fluid level as necessary. Use Mopar ATF type 7176 (P/N 4467721) if additional fluid is required.

Attempt to reproduce the condition described by the vehicle operator. If the gear engagement time exceeds three seconds, the garage shifts are considered delayed and the repair procedure should be performed.

Note: Vehicles with delayed transaxle engagement on start-up, after being parked for several days, are considered normal and will not be affected by performing this bulletin.

Other possible conditions that might cause delayed transaxle engagement are a sticking or frozen PRNDL switch, or a transaxle front pump with excessive gear clearances.

Repair Procedure
1. Raise the vehicle with an appropriate hoist.

2. Clean the transaxle oil pan and mating area thoroughly, preferably with steam.

3. Remove the transaxle oil pan. Remove all sealant from the transaxle oil pan and mating area. Clean the inside of the oil pan and magnet.

4. Check the transaxle oil filter engagement and O-ring condition. Cut or poorly installed O-rings also may cause delayed garage shifts.

5. Separate the transaxle oil filter and O-ring from the valve body and discard.

6. Remove the 18 bolts attaching the valve body and separate the valve body from the transaxle and properly dispose of the transmission fluid.

7. Install the new valve body (P/N 4659085, 41TE; P/N 4659084, 42LE). Torque the attaching bolts to 40 in.-lbs. (5 Nm).

8. Install the new oil filter (P/N 4504048, 41TE; P/N 4796730, 42LE).

9. Apply a 1/8” bead of Mopar RTV sealant, P/N 4318025, or equivalent, on the mounting flange of the transaxle oil pan. Also apply the sealant to the underside of the attaching bolts. Torque the attaching bolts to 165 in.-lbs. (19 Nm).

10. Pour 4 quarts of ATF through the fill tube.

11. Start the engine and allow it to idle for a minimum of one minute. With the parking brake and the service brakes applied, move the gear selector lever momentarily to each gear position. Place the gear selector lever in either Park or Neutral.

12. Check the transaxle fluid level and add an appropriate amount of transmission fluid to bring the level to 1/8” (3 mm) below the ADD mark on the dipstick.

13. Recheck the fluid level after the transaxle is at normal operating temperature. The level should be in the HOT range of the dipstick.

Technical service bulletin courtesy of Mitchell 1.

For additional information, visit www.mitchell1.com.

You May Also Like

Today’s Fuel Pressure Diagnostics

Direct injection pressure is measured with sensors, and the signals are used to determine pump speed and/or volume.

Ever since the fuel pump was moved to the fuel tank, fuel pressure replaced the float height as a measure of fuel system health and performance. Checking the height of the float might have required some disassembly or special tools to bend the arms of the float.

When the shift was made to port or throttle body fuel injection, all a technician needed to diagnose a fuel problem was a set of “noid lights,” a fuel pressure gauge and maybe a multi-meter. Measuring the fuel pressure typically required checking the pressure at idle and under load. Most of the these tools can’t be used on the high pressure side of a direct-injection system because of higher pressures and changes in the injector location and technology. 

ADAS Calibration Tips

Here are 10 tips to follow during ADAS Calibration.

ADAS Calibration Aborts

Knowing the common “hiccups” can save you time and money.

Fuel Pumps and Cranking

Diagnosing the problem comes down to understanding what causes a loss of fuel pressure.

Electric Power Steering Diagnostics

Load management for steering systems.

Other Posts

Solving VW False Fuel Pressure Reading

First, verify the customer did not run out of fuel at the time the DTCs were stored.

vw steering wheel squeak
Tech Tips for Dorman’s OE FIX Steering Tie Rod End Assembly

Read the tech note for tips on installation of this unique fix.

Acura Frozen Starter Causes No Start

Why won’t the engine crank after the vehicle has been exposed to precipitation and then freezing temperatures?

Beating the Tech Shortage Through Mentoring

How understanding the 80/20 Rule and creative mentoring can make the shortage less threatening.