Tech Tip: Volkswagen DTCs P1297 Or P1557 Stored In DTC Memory

Tech Tip: Volkswagen DTCs P1297 Or P1557 Stored In DTC Memory

DTCs P1297 (17705) or P1557 (17965) are stored in DTC memory. This may be caused by intake hoses leaking (during boost conditions), due to incorrect torque on clamps or improper placement, or worn or torn intake hoses, etc.

Model(s) affected: All 1998–2006 1.8L Turbo vehicles.

Condition:

DTCs P1297 (17705) or P1557 (17965) are stored in DTC memory. This may be caused by intake hoses leaking (during boost conditions), due to incorrect torque on clamps or improper placement, or worn or torn intake hoses, etc.

Service Procedures:

Perform an intake system pressure test to detect leaks in the intake system as follows:

1. Separate the intake hose from the mass air flow sensor (MAF) assembly.

2. Remove the crankcase ventilation hose from the PCV valve and close off the crankcase side of the valve with the plug (orange arrow, Fig. 1), hose and clamps (supplied with the turbocharger tester, P/N VAG 1687). fig. 1

Tip: This will disconnect the engine crankcase from the intake system.

3. Insert the air pressure adaptor, P/N VAG 1687/1 (blue arrow, Fig. 1) into the intake hose between the MAF sensor and the intake system (clamp using the existing hose clamp).

Tip: The hose at the throttle assembly will stay connected ­during the test.

Pressure Test:

1. Attach the outlet hose of the turbocharger tester to the fitting on the air pressure adaptor (blue arrow, Fig. 2).

2. Close the outlet valve after the gauge.

3. Back off the pressure regulator knob of the turbocharger tester fully to protect the gauge when shop air supply pressure is applied to the assembly. Fig. 2

4. Attach an air line to the inlet fitting on the turbocharger tester. 

5. Open the valve between the regulator valve and gauge.

6. Adjust the test pressure up to 0.5 bar by turning the regulator valve.

Note: Do not pressurize the system above the 0.5 bar! Doing so will force oil into the intake through the throttle body assembly, causing damage to the engine.

7. Slowly open the outlet valve (after the gauge) to test the hose connections.

8. Observe the pressure gauge for a drop in pressure.

Tip: Some pressure will be lost past the throttle plate.

9. Apply soapy water or leak-check liquid to all intake system connections to check for leaks.

Tip: An ultrasonic tester may also be used to locate leaks.

10. Repair any leaks that are found.

11. Remove the plug from the crankcase ventilation hose.

12. Remove the air pressure adaptor and reinstall the hoses.

Courtesy of Mitchell 1.

You May Also Like

VW/Audi PCV Service

The PCV valve regulates the flow of gases from the crankcase.

Positive crankcase ventilation (PCV) systems have been on just about every vehicle since the late 1960s. The systems route crankcase vapors and droplets into the intake manifold so they are burned in the combustion chamber or catalytic converter. 

The PCV valve uses the vacuum from the intake manifold to regulate the flow of gases from the crankcase. The pintle or ball inside the valve moves in response to the pressure difference between the crankcase and the intake manifold. The valve is typically located between the throttle body and cylinder head on a runner for the intake manifold.

Volvo Engine Service

There are many combinations for the Volvo modular engine.

Servicing Mercedes-Benz AMG Brakes

Take a look at some of the things you need to know in order to service the brakes on a Mercedes-Benz AMG vehicle.

AUDI Outside Air Temperature Readings

Incorrect readings can be avoided.

Mercedes-Benz ABC Suspensions

The system provides great ride & handling, but it can be complicated to service if you do not have the right training.

Other Posts

Don’t Miss The April Digital Edition of ShopOwner

The April issue includes technical and management content and is free to download.

ZF Expands SACHS CDC Shock Line for U.S., Canada

The release expands ZF’s line by more than 70% reflecting growing demand for advanced damping technology in the aftermarket.

Philips Announces Xperion 6000 LED Under Hood Work Light

It features a motion detection switch that allows mechanics to turn the light on and off with a wave of their hand.

Snap-on Announces Latest Software Release

The latest software includes new coverage, guided component tests and features.