Oil Cooler Hoses: Servicing the Transmission

Tech Tip: Don’t Overlook Oil Cooler Hoses When Servicing the Transmission

To avoid comebacks, most service technicians are keenly aware that it pays to replace connected parts whenever a key system component is installed. To do the job right, the first time, technicians will often replace the hoses connected to the water pump, and the fluid lines attached to the fuel pump.

To avoid comebacks, most service technicians are keenly aware that it pays to replace connected parts whenever a key system component is installed. To do the job right, the first time, technicians will often replace the hoses connected to the water pump, and the fluid lines attached to the fuel pump.

The same should be done when servicing the car’s automatic transmission. Gates Corporation engineers say scheduled maintenance of the fluid, filters and pan gasket should also include inspecting, and possibly replacing, the transmission oil cooler hoses. Here’s why.

Transmission cooler lines use high temperature hose. Pressures average 75-125 pounds per square inch (psi) on older cars and can surge to 300 psi on newer, electronically controlled transmissions. A small leak, under pressure, can lead to serious problems.

Leaks may come from the gasket or bearing, or the transmission oil cooler hose assembly. Soft, spongy hose and/or hard, brittle hose are signs that a leak is imminent. Prolonged exposure to ozone, extreme temperatures, both cold and hot, and high-temperature fluids in the assemblies will cause a failure.

High temperatures also will cause O-rings and seals at the coupling interface to become hard and brittle, allowing for a leak path. Although protected against rust and corrosion, environments with high salt concentrations (coastal and northern winter areas), will eventually cause tubing to rust or corrode, necessitating replacement of the assembly.

According to Gates engineers, the most common transmission oil cooler assembly leak is at the hose coupling connection. Constant vibration and flexing where the end of the coupling ferrule joins the hose, cause the hose to crack and leak, a drop at a time. Hoses that are not properly mounted or excessive hose vibration resulting from failed motor mounts will accelerate the leakage.

Gates recommends that technicians replace a transmission cooler line with a new assembly that follows the original equipment design. OEM-designed assemblies allow the automatic transmission fluid (ATF) to properly cool down in the cycle of the fluid, and their tube configurations prevent hose abrasion and heat failure problems that might result from improper routing.

To eliminate the costs and time associated with sourcing OE dealership parts, Gates offers a line of transmission oil cooler hose assemblies consisting of 188 part numbers of the most failure-prone applications.

The line also includes bulk hose, fittings, tools and related components. Gates transmission oil cooler assemblies and components are designed to resist ozone, ambient temperature extremes, high-temp fluids and corrosion. They are OE-equivalent in fit, appearance and performance.

A leaking transmission is a $2,000 repair waiting to happen. So, avoid comebacks, and do the job right the first time.

Courtesy of Gates, www.gates.com/adverts.

You May Also Like

Electric Power Steering Diagnostics

Load management for steering systems.

In the late 1990s, engineers and OEMs predicted a future where 42-volt electrical architecture would be a standard feature on all new vehicles. This high-voltage system was a solution for the power required for loads such as electric power steering. It got as far as an SAE standard so OEMs and suppliers could implement these systems. What happened? The simple answer is that engineers improved how 12-volt power was managed in the vehicle.

Solving VW False Fuel Pressure Reading

First, verify the customer did not run out of fuel at the time the DTCs were stored.

vw steering wheel squeak
Tech Tips for Dorman’s OE FIX Steering Tie Rod End Assembly

Read the tech note for tips on installation of this unique fix.

Acura Frozen Starter Causes No Start

Why won’t the engine crank after the vehicle has been exposed to precipitation and then freezing temperatures?

Strut Sales

It all comes down to educating the customer about the benefits and asking for the sale.

Other Posts

Beating the Tech Shortage Through Mentoring

How understanding the 80/20 Rule and creative mentoring can make the shortage less threatening.

Nissan Key Will Not Start

Nissan keys use radio frequencies (RF) similar to other everyday wireless devices.

Taking the Fear out of ASE Testing

Spring registration now open; Register by June 30.

Audi EVAP Case Study

Let’s look at some of the things that you should know about Audi EVAP systems before trying to tackle such a repair.