Nissan Versa Alignment Specs: Front, Rear Suspension

Nissan Versa Alignment Specs

The front suspension uses a strut and lower control arm. Camber can be adjusted by installing aftermarket cam bolts in the upper bolt holes of the strut and knuckle. Caster is not adjustable. If caster is out of specification, check the control arm. 2007-'11 models have had numerous complaints about the front coil springs breaking. This failure usually results in part of the coil breaking off and the spring falling off its perch. This typically happens during low-speed maneuvers, and the customer may notice a piece of the spring on the ground.

Nissan Versa alignment

The Nissan Versa is the entry-level vehicle that took over from the Sentra, which is now classified as a mid-sized vehicle. The Versa shouldn’t be a problem to align, but you need to be aware of a few quirks.

Front Suspension

The front suspension uses a strut and lower control arm. Camber can be adjusted by installing aftermarket cam bolts in the upper bolt holes of the strut and knuckle. Caster is not adjustable. If caster is out of specification, check the control arm.

2007-‘11 models have had numerous complaints about the front coil springs breaking. This failure usually results in part of the coil breaking off and the spring falling off its perch. This typically happens during low-speed maneuvers, and the customer may notice a piece of the spring on the ground.

If the customer is able to drive the vehicle, it will pull in one direction and will require extra steering effort. Nissan did issue bulletin NTB 11032 concerning noise coming from the front suspension during low speeds. The solution is to install an insulator tube over the top of the spring to solve any noise problems, but spring replacement is recommended if the technician sees any possible problems.

To spot a weak or broken spring, check the ride height. According to Nissan, measure the distance from the top of the wheel well to the ground, which should measure 26.9” in the front and 26.8” in the rear with a full tank of gas.

Nissan alignmentRear Suspension

The rear suspension is a trailing arm beam axle. Toe and camber can be adjusted with aftermarket shims that fit between the hub unit and axle.

Toe adjustments can be made by manipulating the bolts holding the axle mounts to the body. This is very labor intensive and should only be performed as a last resort. Also, without an alignment system that can measure setback and thrust, you could be flying blind. Check Nissan TSB NTB 11060 for more details.

Steering System

The Versa uses electric power steering (EPS). The system uses a torque sensor in the steering column to determine the level of assist as well as a vehicle speed sensor on the transmission. The sensor cluster on the steering column shares position information with the ABS/ESC system through the EPS control module that connects to the CAN bus.

The system can go into a fail-safe mode if it detects conditions that might cause the motor to overheat due to extended current loads, such as a bad thrust angle or a driver fighting a steering pull.

You May Also Like

Toyota Direct Injection? Port Injection? Why Not Both?

Port fuel injection and direct fuel injection systems each have their advantages and disadvantages.

If you’ve serviced import vehicles for at least the past decade, you may have seen a Toyota vehicle that has both direct fuel injection and port fuel injection. You will see port fuel injectors in the intake manifold and a direct injection fuel pump. Toyota calls this system the D-4S or Dynamic Force Engine (the “S” stands for superior) and the earliest application was on the Lexus GS SUV with the V8. The D-4S system is not a “cold start” or “dousing” injector system, like that on V6 engines from the early to late 2000s.

Toyota Squeaking Noise From Rear Suspension 

Follow the repair procedure in this bulletin to address this condition.

Toyota Milliwave Calibration Tips

Calibration is necessary due to several factors affecting the radar’s functionality.

Different Nameplates, Different Expectations

Honda is one of the least concerned manufacturers about system voltages when it comes to reflashing.

Nissan Electro Hydraulic Steering

Nissan’s steering system is susceptible to driver-error.

Other Posts

Key Programming

When it comes to key programming, there are different levels of security access depending on the year, make and model of the vehicle.

Subaru HVAC Diagnostics

On some more modern Subaru vehicles, you might be better off grabbing your scan tool.

New Motor Mount Technology

Engine speed is the primary input that determines the stiffness of the mount.

Subaru Tech Tip: Spiderwebs Blocking The Camera

If the webs can be removed without touching the camera lens, carefully remove them and reassemble the camera.